Connect with us

Breaking News

Plug-in and sail: Meet the electric ferry pioneers


Plug-in and sail: Meet the electric ferry pioneers

Image copyright Adrienne Murray Image caption Thomas Larsen captains Ellen, the world’s biggest electric ferry “Have a pleasant journey,” blurts the tannoy, as the engines ramp up and we pull away from the harbour in Fynshav, southern Denmark.I’m aboard Ellen, an electric-powered ferry, sailing to the island of Ærø, in the west Baltic Sea. On…

Thomas Larsen captains Ellen the world's biggest electric ferryImage copyright
Adrienne Murray

Image caption

Thomas Larsen captains Ellen, the world’s biggest electric ferry

“Have a pleasant journey,” blurts the tannoy, as the engines ramp up and we pull away from the harbour in Fynshav, southern Denmark.

I’m aboard Ellen, an electric-powered ferry, sailing to the island of Ærø, in the west Baltic Sea.

On the ship’s bridge, Captain Thomas Larsen stands behind a panel with controls and electronic charts. “What I can see on these two screens is a power management system,” he points out. “It shows me all my batteries. And how far I can expect to go.”

“The main difference is that I don’t have a full fuel tank. I need to think a lot about how I’m using my power.”

As we talk an alarm starts beeping. “Oh this tells me I do not have power for a new return trip without recharging,” Captain Larsen says calmly.

Powered entirely by batteries, Ellen is something of a Tesla among ferries. Fully charged, the 60m vessel can sail 22 nautical miles with up to 200 passengers and 30 cars onboard.

Image copyright
Adrienne Murray

Image caption

Ellen has a range of 22 nautical miles

That’s a roughly 40km (25-mile) round-trip, and seven times further than other electric ferries.

Ellen replaces an older diesel-powered vessel, and in the onboard cafe passengers welcome the change.

“It doesn’t make so much noise. And no smoke from the diesel – it’s good,” one traveller tells me.

“It’s very quiet. You don’t feel anything. It’s a great idea also for the environment,” says another.

“Ferry shipping in general is very dirty business,” says Halfdan Abrahamsen, an information officer from Ærø EnergyLab, as he shows me around.

More Technology of Business

Ships usually use marine diesel or heavy fuel oil, “which is just about the bottom of the food chain when it comes to product from refineries,” says Mr Abrahamsen.

The only oil onboard Ellen is for the gearbox and in the kitchen for making French fries, he says.

The emission-free ferry is expected to reduce CO2 emissions by 2,000 tonnes a year. It’s part of an EU-backed project to develop green ferries for longer routes.

Beyond a set of heavy metal doors, lies the engine and two battery rooms, where 840 lithium-ion batteries supplied by Swiss firm Leclanché, are stacked from floor to ceiling.

Image copyright
Adrienne Murray

Image caption

Two battery rooms house 840 lithium-ion batteries

Totalling 4.3MWh this is the largest battery capacity at sea and equivalent to the average amount of electricity a UK household consumes each year.

“It is the biggest electric ferry and the longest distance operating ferry in the world at the moment,” says Kimmo Rauma, vice-president of Danfoss Editron, the Finland-based company behind the electrical propulsion and charging technology.

After a 70 minute voyage, Ellen arrives at the harbour in Søby and moors alongside the charging station.

A mechanical arm plugs in and recharges the batteries in less than 25 minutes with clean energy supplied by local wind turbines.

Ellen is not fully operational just yet, and it hasn’t all been smooth sailing. Building a boat with so many batteries is complex and since being launched some battery cells have been replaced.

Image copyright
Adrienne Murray

Image caption

Trine Heinemann says Ellen’s running costs are a quarter that of a diesel ferry

“They’re getting lighter and more energy dense, but they’re still heavy,” Trine Heinemann, the E-Ferry project coordinator explains, as we stand on the dockside.

“The more energy you need, the more batteries you need, the more weight you add. You then have to start thinking about how do we take other weight away from the ship? How do you build the most energy-efficient ship?”

A lower resistance design and more lightweight materials were used, contributing to Ellen’s low running costs.

“We are paying maybe 25% of what you would pay for running a similar diesel vessel.” says Ms Heinemann. “So that’s the significant saving.”

Maintenance costs are much lower too. A diesel engine has about 30,000 moving parts, in an electric motor it’s just the bearings that need maintenance, Dr Rauma says.

Image copyright
Adrienne Murray

Image caption

The green box on the right recharges Ellen’s batteries

The ferry has cost €21.3m (US$23.6m; £18.3m), with the EU’s Horizon 2020 programme funding €15m.

“It’s maybe 40% more expensive than a conventional diesel vessel,” Ms Heinemann says.

“Then you still have the transformer and the electrical infrastructure. So in terms of establishing an electrical vessel, we are looking at a significantly higher cost.”

So while battery power is certainly greener, is it commercially viable? The team believes so.

“Some say within 14 months you break even and then it’s saving from then on. We’re being a little bit more conservative and saying maybe four or five years,” says Ms Heinemann.

At Søby Shipyard, where Ellen was built, chief executive Roar Falkenberg thinks costs will come down.

“Ellen was a prototype. I think when we build the next Ellen, it will be only cost a bit more than a normal ferry. And if you look three to five years ahead, I think the price will be the same.”

Did You See This CB Softwares?


Join Affiliate Bots Right Away

Image copyright
Adrienne Murray

Image caption

Electric engines will require less maintenance

Batteries are getting more cost-competitive says Dr Tristan Smith, a shipping and energy expert from University College London, thanks largely to better technology and stricter emissions rules.

“If you have strong air quality regulation then you aren’t able to burn the worst quality marine fuels,” he says, “which then makes the battery more competitive, because it’s now competing against the more expensive fossil fuel.”

The shipping industry is responsible for around 3% of global CO2 and greenhouse gas emissions. In April 2018, the International Maritime Organisation set new targets to reduce these emissions by “at least 50% by 2050 compared to 2008” levels.

That’s spurring industry players to explore new emission-cutting measures including alternatives fuels like LNG, biofuel, also hydrogen and ammonia which Dr Smith thinks show most promise.

Image copyright

Image caption

Norled is part of a hydrogen-powered ferry project

Since the first fully-electric ferry was launched in Norway four years ago using Siemens technology, Nordic countries have lead a shift towards hybrid and electric power. Operator Norled now plans to build the world’s first hydrogen-electric ferry.

“The technology is ready,” says Danfoss Editron’s Kimmo Rauma. “The question is that the maritime industry is not the fastest to change.”

His firm has supplied electric technology for patrol-boats, icebreakers, and fish farming service boats.

It also developed Asia’s first e-ferry in Taiwan. He says retrofitting older diesel vessels with electric engines, particularly in city harbour areas, is a “big opportunity” to reduce pollution.

However experts say that scaling up battery power for large ships has significant limitations.

“The common denominator for successful battery use is that the vessels operate close to shore,” says Maria Skipper Schwenn, a director at industry body, Danish Shipping.

“The operational reach is limited simply due to the capacity of the battery itself. It’s simply not possible today when you are sailing more than 10 or 20 days at sea. In addition to that you need an enormous charging capacity in the port.”

“With the technology we have right now… it doesn’t seem like a viable solution for the deep-sea shipping. But for ferries, supply ships and tugboats, it’s an excellent solution.”

Back at Søby Shipyard, Roar Falkenberg agrees. “The key is how much energy can you store in the battery. If you have to sail from England to the United States, you need a lot! And then you can’t have any cargo, you can only have batteries. Maybe in 10 years, 15 years, there will be other ways for longer ship routes.”

Click to comment

You must be logged in to post a comment Login

Leave a Reply

To Top